CoChat
Sign Up
Cited by 264Thermochemical Biomass Conversion ProcessesCatalysis for Biomass ConversionZeolite Catalysis and Synthesis

The DOI matches its Crossref record; 9 of the 9 references it cites were found in a registry or an index.

A review on selective production of value-added chemicals via catalytic pyrolysis of lignocellulosic biomass

Dai, Leilei, Wang, Yunpu, Liu, Yuhuan, He, Chao, Ruan, Roger, Yu, Zhenting, Jiang, Lin, Zeng, Zihong, Wu, Qiuhao·2020·Science of The Total Environment
DOI 10.1016/j.scitotenv.2020.142386
Open this paper in CoChat — free account

Abstract

Increasing fossil fuel consumption and global warming has been driving the worldwide revolution towards renewable energy. Biomass is abundant and low-cost resource whereas it requires environmentally friendly and cost-effective conversion technique. Pyrolysis of biomass into valuable bio-oil has attracted much attention in the past decades due to its feasibility and huge commercial outlook. However, the complex chemical compositions and high water content in bio-oil greatly hinder the large-scale application and commercialization. Therefore, catalytic pyrolysis of biomass for selective production of specific chemicals will stand out as a unique pathway. This review aims to improve the understanding for the process by illustrating the chemistry of non-catalytic and catalytic pyrolysis of biomass at the temperatures ranging from 400 to 650 °C. The focus is to introduce recent progress about producing value-added hydrocarbons, phenols, anhydrosugars, and nitrogen-containing compounds from catalytic pyrolysis of biomass over zeolites, metal oxides, etc. via different reaction pathways including cracking, Diels-Alder/aromatization, ketonization/aldol condensation, and ammoniation. The potential challenges and future directions for this technique are discussed in deep.

Overview

Integrity signals

Registry

Crossref · 10.1016/j.scitotenv.2020.142386

Cites

9 of 9 references verified0 citation errors · 0 not checkable

Statistics

Recomputing p-values needs the paper’s full text.

Verification

Claims the paper makes

This paper’s full text isn’t openly available, so its claims and self-check weren’t run. The registry and citation checks still apply.

Claims other papers make about this one

Each is checked against this paper’s own text: does it say what the citing paper says it does?

  • Due to the acidic sites on Ni/γ-Al2O3, small molecular substances could undergo further transformations to yield olefins.

    “Due to the acidic sites on Ni/γ-Al2O3, these small molecular substances could undergo further transformations to yield olefins (Lin et al., 2020; Dai et al., 2020).”

    From Catalytic pyrolysis of liquor-industry waste: Product and mechanism analysis (2024) · cites this paper as Dai et al., 2020

  • The increase in hydrocarbon content in bio-oil primarily arose from deoxidation of O-species and phenolic compounds facilitated by Ni/γ-Al2O3.

    “The increase in hydrocarbon content in bio-oil primarily arose from the deoxidation of O-species and phenolic compounds facilitated by Ni/γ-Al2O3.”

    From Catalytic pyrolysis of liquor-industry waste: Product and mechanism analysis (2024) · cites this paper as Dai et al., 2020

Citations

Cites

Flagged first, then by citations

Research works printed but not linked: 196

  1. Adjaye, 1995, Production of hydrocarbons by catalytic upgrading of a fast pyrolysis bio-oil. Part I: conversion over various catalysts, Fuel Process. Technol., 45, 161, 10.1016/0378-3820(95)00034-5 · DOI
  2. Akhtar, 2012, A review on operating parameters for optimum liquid oil yield in biomass pyrolysis, Renew. Sust. Energ. Rev., 16, 5101, 10.1016/j.rser.2012.05.033 · DOI · Paper page
  3. Al-Sabawi, 2012, Fluid catalytic cracking of biomass-derived oils and their blends with petroleum feedstocks: a review, Energy Fuel, 26, 5355, 10.1021/ef3006417 · DOI
  4. Ansari, 2019, Investigating production of hydrocarbon rich bio-oil from grassy biomass using vacuum pyrolysis coupled with online deoxygenation of volatile products over metallic iron, Renew. Energy, 130, 305, 10.1016/j.renene.2018.06.052 · DOI
  5. Antal, 1995, Cellulose pyrolysis kinetics: the current state of knowledge, Ind. Eng. Chem. Res., 34, 703, 10.1021/ie00042a001 · DOI
  6. Ateş, 2008, Evaluation of the role of the pyrolysis temperature in straw biomass samples and characterization of the oils by GC/MS, Energy Fuel, 22, 1936, 10.1021/ef7006276 · DOI · Paper page
  7. Balat, 2008, Mechanisms of thermochemical biomass conversion processes. Part 1: reactions of pyrolysis, Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 30, 620, 10.1080/15567030600817258 · DOI
  8. Bennett, 2009, Extraction and hydrolysis of levoglucosan from pyrolysis oil, Bioresour. Technol., 100, 6059, 10.1016/j.biortech.2009.06.067 · DOI
  9. Bicalho, 2019, Quality of data for estimating GHG emissions in biofuel regulations is unknown: a review of default values related to sugarcane and corn ethanol, J. Clean. Prod., 239, 10.1016/j.jclepro.2019.117903 · DOI
  10. Blasi, 2010, Pyrolysis of corncobs catalyzed by zinc chloride for furfural production, Ind. Eng. Chem. Res., 49, 9743, 10.1021/ie101067v · DOI
  11. Blasi, 2010, Biomass screening for the production of furfural via thermal decomposition, Ind. Eng. Chem. Res., 49, 2658, 10.1021/ie901731u · DOI
  12. Boroson, 1989, Product yields and kinetics from the vapor phase cracking of wood pyrolysis tars, AICHE J., 35, 120, 10.1002/aic.690350113 · DOI
  13. Branca, 2012, Catalyst screening for the production of furfural from corncob pyrolysis, Energy Fuel, 26, 1520, 10.1021/ef202038n · DOI
  14. Bu, 2011, Phenol and phenolics from lignocellulosic biomass by catalytic microwave pyrolysis, Bioresour. Technol., 102, 7004, 10.1016/j.biortech.2011.04.025 · DOI
  15. Bu, 2012, Production of phenols and biofuels by catalytic microwave pyrolysis of lignocellulosic biomass, Bioresour. Technol., 108, 274, 10.1016/j.biortech.2011.12.125 · DOI
  16. Bu, 2013, Renewable phenols production by catalytic microwave pyrolysis of Douglas fir sawdust pellets with activated carbon catalysts, Bioresour. Technol., 142, 546, 10.1016/j.biortech.2013.05.073 · DOI
  17. Bu, 2014, Bio-based phenols and fuel production from catalytic microwave pyrolysis of lignin by activated carbons, Bioresour. Technol., 162, 142, 10.1016/j.biortech.2014.03.103 · DOI
  18. Cacchi, 2005, Synthesis and functionalization of indoles through palladium-catalyzed reactions, Chem. Rev., 105, 2873, 10.1021/cr040639b · DOI
  19. Cai, 2016, Preparation of refined bio-oil by catalytic transformation of vapors derived from vacuum pyrolysis of rape straw over modified HZSM-5, Energy, 102, 95, 10.1016/j.energy.2016.02.051 · DOI
  20. Cao, 2018, Lignin valorization for the production of renewable chemicals: state-of-the-art review and future prospects, Bioresour. Technol., 269, 465, 10.1016/j.biortech.2018.08.065 · DOI
  21. Carlson, 2008, Green gasoline by catalytic fast pyrolysis of solid biomass derived compounds, ChemSusChem, 1, 397, 10.1002/cssc.200800018 · DOI
  22. Carlson, 2009, Mechanistic insights from isotopic studies of glucose conversion to aromatics over ZSM-5, ChemCatChem, 1, 107, 10.1002/cctc.200900130 · DOI
  23. Carlson, 2011, Production of green aromatics and olefins by catalytic fast pyrolysis of wood sawdust, Energy Environ. Sci., 4, 145, 10.1039/C0EE00341G · DOI
  24. Chang, 2016, Lewis acid zeolites for tandem Diels–Alder cycloaddition and dehydration of biomass-derived dimethylfuran and ethylene to renewable p-xylene, Green Chem., 18, 1368, 10.1039/C5GC02164B · DOI
  25. Chang, 1977, The conversion of methanol and other O-compounds to hydrocarbons over zeolite catalysts, J. Catal., 47, 249, 10.1016/0021-9517(77)90172-5 · DOI
  26. Che, 2019, Influence of physicochemical properties of metal modified ZSM-5 catalyst on benzene, toluene and xylene production from biomass catalytic pyrolysis, Bioresour. Technol., 278, 248, 10.1016/j.biortech.2019.01.081 · DOI
  27. Chen, 2018, Investigation on biomass nitrogen-enriched pyrolysis: influence of temperature, Bioresour. Technol., 249, 247, 10.1016/j.biortech.2017.10.022 · DOI
  28. Chen, 2017, Catalytic fast pyrolysis of biomass to produce furfural using heterogeneous catalysts, J. Anal. Appl. Pyrolysis, 127, 292, 10.1016/j.jaap.2017.07.022 · DOI
  29. Cheng, 2012, Production of targeted aromatics by using Diels–Alder classes of reactions with furans and olefins over ZSM-5, Green Chem., 14, 3114, 10.1039/c2gc35767d · DOI
  30. Cheng, 2012, Production of renewable aromatic compounds by catalytic fast pyrolysis of lignocellulosic biomass with bifunctional Ga/ZSM-5 catalysts, Angew. Chem. Int. Ed., 51, 1387, 10.1002/anie.201107390 · DOI · Paper page
  31. Cheng, 2012, Production of p-xylene from biomass by catalytic fast pyrolysis using ZSM-5 catalysts with reduced pore openings, Angew. Chem. Int. Ed., 51, 11097, 10.1002/anie.201205230 · DOI
  32. Chu, 2013, The pyrolysis chemistry of a β-O-4 type oligomeric lignin model compound, Green Chem., 15, 125, 10.1039/C2GC36332A · DOI
  33. Corma, 2007, Processing biomass-derived oxygenates in the oil refinery: catalytic cracking (FCC) reaction pathways and role of catalyst, J. Catal., 247, 307, 10.1016/j.jcat.2007.01.023 · DOI
  34. Custodis, 2016, Catalytic fast pyrolysis of lignin over high-surface-area mesoporous aluminosilicates: effect of porosity and acidity, ChemSusChem, 9, 1134, 10.1002/cssc.201600105 · DOI · Paper page
  35. Dai, 2019, Bridging the relationship between hydrothermal pretreatment and co-pyrolysis: effect of hydrothermal pretreatment on aromatic production, Energy Convers. Manag., 180, 36, 10.1016/j.enconman.2018.10.079 · DOI · Paper page
  36. Dai, 2019, Integrated process of lignocellulosic biomass torrefaction and pyrolysis for upgrading bio-oil production: a state-of-the-art review, Renew. Sust. Energ. Rev., 107, 20, 10.1016/j.rser.2019.02.015 · DOI
  37. de Caprariis, 2017, Hydrothermal liquefaction of biomass: influence of temperature and biomass composition on the bio-oil production, Fuel, 208, 618, 10.1016/j.fuel.2017.07.054 · DOI
  38. Demirbaş, 2005, Thermochemical conversion of biomass to liquid products in the aqueous medium, Energy Sources, 27, 1235, 10.1080/009083190519357 · DOI
  39. Dobele, 1999, Cellulose dehydration and depolymerization reactions during pyrolysis in the presence of phosphoric acid, J. Anal. Appl. Pyrolysis, 49, 307, 10.1016/S0165-2370(98)00126-0 · DOI
  40. Dobele, 2005, Application of catalysts for obtaining 1,6-anhydrosaccharides from cellulose and wood by fast pyrolysis, J. Anal. Appl. Pyrolysis, 74, 401, 10.1016/j.jaap.2004.11.031 · DOI
  41. Dorado, 2015, Origin of carbon in aromatic and olefin products derived from HZSM-5 catalyzed co-pyrolysis of cellulose and plastics via isotopic labeling, Appl. Catal., B, 162, 338, 10.1016/j.apcatb.2014.07.006 · DOI
  42. Doroshenko, 2019, Selective microwave-assisted pyrolysis of cellulose towards Levoglucosenone using clay catalysts, ChemSusChem, 12, 5224, 10.1002/cssc.201903026 · DOI
  43. Engtrakul, 2016, Effect of ZSM-5 acidity on aromatic product selectivity during upgrading of pine pyrolysis vapors, Catal. Today, 269, 175, 10.1016/j.cattod.2015.10.032 · DOI
  44. Evans, 1987, Molecular characterization of the pyrolysis of biomass, Energy Fuel, 1, 123, 10.1021/ef00002a001 · DOI
  45. Fabbri, 2007, Effect of zeolites and nanopowder metal oxides on the distribution of chiral anhydrosugars evolved from pyrolysis of cellulose: An analytical study, J. Anal. Appl. Pyrolysis, 80, 24, 10.1016/j.jaap.2006.12.025 · DOI
  46. Fabbri, 2007, Pyrolysis of cellulose catalysed by nanopowder metal oxides: production and characterisation of a chiral hydroxylactone and its role as building block, Green Chem., 9, 1374, 10.1039/b707943e · DOI
  47. Fan, 2019, Selective production of anhydrosugars and furfural from fast pyrolysis of corncobs using sulfuric acid as an inhibitor and catalyst, Chem. Eng. J., 358, 743, 10.1016/j.cej.2018.10.014 · DOI
  48. Fanchiang, 2012, Catalytic fast pyrolysis of furfural over H-ZSM-5 and Zn/H-ZSM-5 catalysts, Appl. Catal., A, 419-420, 102, 10.1016/j.apcata.2012.01.017 · DOI
  49. Fischer, 2015, The effect of temperature, heating rate, and ZSM-5 catalyst on the product selectivity of the fast pyrolysis of spent coffee grounds, RSC Adv., 5, 29252, 10.1039/C5RA00212E · DOI
  50. Foster, 2012, Optimizing the aromatic yield and distribution from catalytic fast pyrolysis of biomass over ZSM-5, Appl. Catal., A, 423-424, 154, 10.1016/j.apcata.2012.02.030 · DOI
  51. French, 2010, Catalytic pyrolysis of biomass for biofuels production, Fuel Process. Technol., 91, 25, 10.1016/j.fuproc.2009.08.011 · DOI
  52. Furneaux, 1988, A novel hydroxylactone from the Lewis acid catalysed pyrolysis of cellulose, Journal of the Chemical Society, Perkin Transactions I, 49, 10.1039/p19880000049 · DOI
  53. Gaertner, 2010, Ketonization reactions of carboxylic acids and esters over ceria-zirconia as biomass-upgrading processes, Ind. Eng. Chem. Res., 49, 6027, 10.1021/ie1004338 · DOI
  54. Gayubo, 2004, Transformation of oxygenate components of biomass pyrolysis oil on a HZSM-5 zeolite. I. Alcohols and phenols, Ind. Eng. Chem. Res., 43, 2610, 10.1021/ie030791o · DOI
  55. Gayubo, 2004, Transformation of oxygenate components of biomass pyrolysis oil on a HZSM-5 zeolite. II. Aldehydes, ketones, and acids, Ind. Eng. Chem. Res., 43, 2619, 10.1021/ie030792g · DOI
  56. Green, 2016, Diels–Alder cycloaddition of 2-methylfuran and ethylene for renewable toluene, Appl. Catal., B, 180, 487, 10.1016/j.apcatb.2015.06.044 · DOI
  57. Gürbüz, 2010, Dual-bed catalyst system for C–C coupling of biomass-derived oxygenated hydrocarbons to fuel-grade compounds, Green Chem., 12, 223, 10.1039/b920369a · DOI
  58. Hakim, 2013, Catalytic upgrading of the light fraction of a simulated bio-oil over CeZrOx catalyst, Appl. Catal., B, 142-143, 368, 10.1016/j.apcatb.2013.05.021 · DOI
  59. Hamburg, 1988, Study on low mass thermal degradation products of milled wood lignins by thermogravimetry-mass-spectrometry, Wood Sci. Technol., 22, 323, 10.1007/BF00353322 · DOI
  60. Hernando, 2018, Engineering the acidity and accessibility of the zeolite ZSM-5 for efficient bio-oil upgrading in catalytic pyrolysis of lignocellulose, Green Chem., 20, 3499, 10.1039/C8GC01722K · DOI
  61. Hertzog, 2018, Catalytic fast pyrolysis of biomass over microporous and hierarchical zeolites: characterization of heavy products, ACS Sustain. Chem. Eng., 6, 4717, 10.1021/acssuschemeng.7b03837 · DOI
  62. Hu, 2020, Insight into the formation mechanism of levoglucosenone in phosphoric acid-catalyzed fast pyrolysis of cellulose, J. Energy Chem., 43, 78, 10.1016/j.jechem.2019.08.001 · DOI
  63. Huang, 2013, Theoretical studies on pyrolysis mechanism of guaiacol as lignin model compound, J. Renewable Sustainable Energy, 5, 10.1063/1.4816497 · DOI
  64. Huber, 2006, Synthesis of transportation fuels from biomass: chemistry, catalysts, and engineering, Chem. Rev., 106, 4044, 10.1021/cr068360d · DOI
  65. Iliopoulou, 2012, Catalytic upgrading of biomass pyrolysis vapors using transition metal-modified ZSM-5 zeolite, Appl. Catal., B, 127, 281, 10.1016/j.apcatb.2012.08.030 · DOI
  66. Iliopoulou, 2014, Pilot-scale validation of Co-ZSM-5 catalyst performance in the catalytic upgrading of biomass pyrolysis vapours, Green Chem., 16, 662, 10.1039/C3GC41575A · DOI
  67. Jae, 2011, Investigation into the shape selectivity of zeolite catalysts for biomass conversion, J. Catal., 279, 257, 10.1016/j.jcat.2011.01.019 · DOI
  68. Jia, 2017, Catalytic fast pyrolysis of biomass: superior selectivity of hierarchical zeolites to aromatics, Green Chem., 19, 5442, 10.1039/C7GC02309J · DOI
  69. Johansson, 2008, The hydrocarbon pool in ethanol-to-gasoline over HZSM-5 catalysts, Catal, Letters, 127, 1
  70. Kalogiannis, 2018, First pilot scale study of basic vs acidic catalysts in biomass pyrolysis: deoxygenation mechanisms and catalyst deactivation, Appl. Catal., B, 238, 346, 10.1016/j.apcatb.2018.07.016 · DOI
  71. Katada, 1997, Synthesis of aniline from phenol and ammonia over zeolite beta, Progress in Zeolite and Microporous Materials, 105, 1227
  72. Kelkar, 2014, Aromatics from biomass pyrolysis vapour using a bifunctional mesoporous catalyst, Green Chem., 16, 803, 10.1039/C3GC41350K · DOI
  73. Kikhtyanin, 2014, Aldol condensation of furfural and acetone on zeolites, Catal. Today, 227, 154, 10.1016/j.cattod.2013.10.059 · DOI
  74. Kikhtyanin, 2015, Toward understanding of the role of Lewis acidity in aldol condensation of acetone and furfural using MOF and zeolite catalysts, Catal. Today, 243, 158, 10.1016/j.cattod.2014.08.016 · DOI
  75. Kim, 2015, Production, separation and applications of phenolic-rich bio-oil--a review, Bioresour. Technol., 178, 90, 10.1016/j.biortech.2014.08.121 · DOI
  76. Kim, 2015, Catalytic pyrolysis of lignin over HZSM-5 catalysts: effect of various parameters on the production of aromatic hydrocarbon, J. Anal. Appl. Pyrolysis, 114, 273, 10.1016/j.jaap.2015.06.007 · DOI
  77. Krishna, 2018, Oxygenated commodity chemicals from chemo-catalytic conversion of biomass derived heterocycles, AICHE J., 64, 1910, 10.1002/aic.16172 · DOI
  78. Kumar, 2019, Bio-oil upgrading with catalytic pyrolysis of biomass using copper/zeolite-nickel/zeolite and copper-nickel/zeolite catalysts, Bioresour. Technol., 279, 404, 10.1016/j.biortech.2019.01.067 · DOI
  79. Lappas, 2002, Biomass pyrolysis in a circulating fluid bed reactor for the production offuels and chemicals, Fuel, 81, 2087, 10.1016/S0016-2361(02)00195-3 · DOI
  80. Li, 2007, Influence of temperature on the formation of oil from pyrolyzing palm oil wastes in a fixed bed reactor, Energy Fuel, 21, 2398, 10.1021/ef060548c · DOI
  81. Li, 2013, Improving the aromatic production in catalytic fast pyrolysis of cellulose by co-feeding low-density polyethylene, Appl. Catal., A, 455, 114, 10.1016/j.apcata.2013.01.038 · DOI
  82. Li, 2014, Enhancing the production of renewable petrochemicals by co-feeding of biomass with plastics in catalytic fast pyrolysis with ZSM-5 zeolites, Appl. Catal., A, 481, 173, 10.1016/j.apcata.2014.05.015 · DOI
  83. Liang, 2016, Selective aldol condensation of biomass-derived levulinic acid and furfural in aqueous-phase over MgO and ZnO, Green Chem., 18, 3430, 10.1039/C6GC00118A · DOI
  84. Lin, 2009, Kinetics and mechanism of cellulose pyrolysis, J. Physical Chem. C, 113, 20097, 10.1021/jp906702p · DOI · Paper page
  85. Lindstrom, 2019, Competing reactions limit levoglucosan yield during fast pyrolysis of cellulose, Green Chem., 21, 178, 10.1039/C8GC03461C · DOI
  86. Liu, 2014, Catalytic fast pyrolysis of lignocellulosic biomass, Chem. Soc. Rev., 43, 7594, 10.1039/C3CS60414D · DOI
  87. Liu, 2017, Bio-oil production from sequential two-step catalytic fast microwave-assisted biomass pyrolysis, Fuel, 196, 261, 10.1016/j.fuel.2017.01.116 · DOI
  88. Long, 2013, Biomass resources and their bioenergy potential estimation: a review, Renew. Sust. Energ. Rev., 26, 344, 10.1016/j.rser.2013.05.035 · DOI
  89. Lu, 2009, Catalytic pyrolysis of cellulose with sulfated metal oxides: a promising method for obtaining high yield of light furan compounds, Bioresour. Technol., 100, 4871, 10.1016/j.biortech.2009.04.068 · DOI
  90. Lu, 2011, Selective fast pyrolysis of biomass impregnated with ZnCl2 to produce furfural: analytical Py-GC/MS study, J. Anal. Appl. Pyrolysis, 90, 204, 10.1016/j.jaap.2010.12.007 · DOI
  91. Lu, 2011, Selective fast pyrolysis of biomass impregnated with ZnCl2: furfural production together with acetic acid and activated carbon as by-products, J. Anal. Appl. Pyrolysis, 91, 273, 10.1016/j.jaap.2011.03.002 · DOI
  92. Lu, 2014, Catalytic fast pyrolysis of cellulose and biomass to produce levoglucosenone using magnetic SO4(2-)/TiO2-Fe3O4, Bioresour. Technol., 171, 10, 10.1016/j.biortech.2014.08.075 · DOI
  93. Lu, 2018, Selective preparation of monocyclic aromatic hydrocarbons from catalytic cracking of biomass fast pyrolysis vapors over Mo 2 N/HZSM-5 catalyst, Fuel Process. Technol., 173, 134, 10.1016/j.fuproc.2018.01.017 · DOI
  94. Lu, 2018, Catalytic fast pyrolysis of sugarcane bagasse using activated carbon catalyst in a hydrogen atmosphere to selectively produce 4-ethyl phenol, J. Anal. Appl. Pyrolysis, 136, 125, 10.1016/j.jaap.2018.10.014 · DOI
  95. Mettler, 2012, Revealing pyrolysis chemistry for biofuels production: conversion of cellulose to furans and small oxygenates, Energy Environ. Sci., 5, 5414, 10.1039/C1EE02743C · DOI
  96. Mettler, 2012, Pyrolytic conversion of cellulose to fuels: levoglucosan deoxygenation via elimination and cyclization within molten biomass, Energy Environ. Sci., 5, 7864, 10.1039/c2ee21305b · DOI
  97. Mettler, 2012, Top ten fundamental challenges of biomass pyrolysis for biofuels, Energy Environ. Sci., 5, 7797, 10.1039/c2ee21679e · DOI
  98. Meunier, 2012, Influence of crystal size and probe molecule on diffusion in hierarchical ZSM-5 zeolites prepared by desilication, Microporous Mesoporous Materials, 148, 115, 10.1016/j.micromeso.2011.08.002 · DOI
  99. Mihalcik, 2011, Screening acidic zeolites for catalytic fast pyrolysis of biomass and its components, J. Anal. Appl. Pyrolysis, 92, 224, 10.1016/j.jaap.2011.06.001 · DOI · Paper page
  100. Moazeni, 2019, Enzymatic transesterification for biodiesel production from used cooking oil, a review, J. Clean. Prod., 216, 117, 10.1016/j.jclepro.2019.01.181 · DOI
  101. Mortensen, 2011, A review of catalytic upgrading of bio-oil to engine fuels, Appl. Catal., A, 407, 1, 10.1016/j.apcata.2011.08.046 · DOI
  102. Mu, 2013, Lignin pyrolysis components and upgrading—technology review, BioEnergy Research, 6, 1183, 10.1007/s12155-013-9314-7 · DOI
  103. Mullen, 2010, Catalytic pyrolysis-GC/MS of lignin from several sources, Fuel Process. Technol., 91, 1446, 10.1016/j.fuproc.2010.05.022 · DOI · Paper page
  104. Naqvi, 2014, Catalytic pyrolysis of paddy husk in a drop type pyrolyzer for bio-oil production: the role of temperature and catalyst, J. Anal. Appl. Pyrolysis, 106, 57, 10.1016/j.jaap.2013.12.009 · DOI
  105. Naron, 2019, Influence of impregnated catalyst on the phenols production from pyrolysis of hardwood, softwood, and herbaceous lignins, Ind. Crop. Prod., 131, 348, 10.1016/j.indcrop.2019.02.001 · DOI
  106. Naron, 2019, Production of phenols from pyrolysis of sugarcane bagasse lignin: catalyst screening using thermogravimetric analysis – thermal desorption – gas chromatography – mass spectroscopy, J. Anal. Appl. Pyrolysis, 138, 120, 10.1016/j.jaap.2018.12.015 · DOI
  107. Neumann, 2012, Novel hierarchical cerium-incorporated MFI zeolite catalysts for the catalytic fast pyrolysis of lignocellulosic biomass, ACS Catal., 2, 642, 10.1021/cs200648q · DOI
  108. Neupane, 2015, Effect of torrefaction on biomass structure and hydrocarbon production from fast pyrolysis, Green Chem., 17, 2406, 10.1039/C4GC02383H · DOI
  109. Olcese, 2013, Gas-phase hydrodeoxygenation of guaiacol over iron-based catalysts. Effect of gases composition, iron load and supports (silica and activated carbon), Appl. Catal., B, 129, 528, 10.1016/j.apcatb.2012.09.043 · DOI
  110. Olsbye, 2012, Conversion of methanol to hydrocarbons: how zeolite cavity and pore size controls product selectivity, Angew. Chem. Int. Ed., 51, 5810, 10.1002/anie.201103657 · DOI
  111. Paine, 2007, Carbohydrate pyrolysis mechanisms from isotopic labeling, J. Anal. Appl. Pyrolysis, 80, 297, 10.1016/j.jaap.2007.03.007 · DOI
  112. Park, 2007, Conversion of the pyrolytic vapor of radiata pine over zeolites, J. Ind. Eng. Chem., 13, 182
  113. Pattiya, 2010, Evaluation of catalytic pyrolysis of cassava rhizome by principal component analysis, Fuel, 89, 244, 10.1016/j.fuel.2009.07.003 · DOI
  114. Patwardhan, 2011, Understanding the fast pyrolysis of lignin, ChemSusChem, 4, 1629, 10.1002/cssc.201100133 · DOI
  115. Persson, 2019, Catalytic pyrolysis over transition metal-modified zeolites: a comparative study between catalyst activity and deactivation, J. Anal. Appl. Pyrolysis, 138, 54, 10.1016/j.jaap.2018.12.005 · DOI
  116. Pham, 2012, Aqueous-phase ketonization of acetic acid over Ru/TiO2/carbon catalysts, J. Catal., 295, 169, 10.1016/j.jcat.2012.08.012 · DOI
  117. Pham, 2013, Ketonization of carboxylic acids: mechanisms, catalysts, and applications in bio-oil upgrading, ACS Catal., 3, 2456, 10.1021/cs400501h · DOI
  118. Piskorz, 1986, On the mechanism of the rapid pyrolysis of cellulose, J. Anal. Appl. Pyrolysis, 9, 121, 10.1016/0165-2370(86)85003-3 · DOI
  119. Platon, 2012, Progress in palladium-based catalytic systems for the sustainable synthesis of annulated heterocycles: a focus on indole backbones, Chem. Soc. Rev., 41, 3929, 10.1039/c2cs15350e · DOI
  120. Ponder, 1992, Influence of linkage position and orientation in pyrolysis of polysaccharides: a study of several glucans, J. Anal. Appl. Pyrolysis, 22, 217, 10.1016/0165-2370(92)85015-D · DOI
  121. Pütün, 2009, Rapid pyrolysis of olive residue. 2. Effect of catalytic upgrading of pyrolysis vapors in a two-stage fixed-bed reactor, Energy Fuel, 23, 2248, 10.1021/ef800978m · DOI
  122. Qi, 2006, Catalytic pyrolysis of several kinds of bamboos over zeolite NaY, Green Chem., 8, 183, 10.1039/B510602H · DOI
  123. Qi, 2019, Selective production of aromatics by catalytic fast pyrolysis of furan with in situ dehydrogenation of propane, ACS Catal., 9, 2626, 10.1021/acscatal.8b04859 · DOI
  124. Rabemanolontsoa, 2013, Comparative study on chemical composition of various biomass species, RSC Adv., 3, 3946, 10.1039/c3ra22958k · DOI
  125. Rathnayake, 2018, Process simulation based life cycle assessment for bioethanol production from cassava, cane molasses, and rice straw, J. Clean. Prod., 190, 24, 10.1016/j.jclepro.2018.04.152 · DOI
  126. Rezaei, 2014, Production of green aromatics and olefins by catalytic cracking of oxygenate compounds derived from biomass pyrolysis: a review, Appl. Catal., A, 469, 490, 10.1016/j.apcata.2013.09.036 · DOI
  127. Richard, 1991, Influence of metal ions and of salts on products from pyrolysis of wood: applications to thermochemical processing of newsprint and biomass, J. Anal. Appl. Pyrolysis, 21, 133, 10.1016/0165-2370(91)80021-Y · DOI
  128. Rolin, 1983, Catalytic conversion of biomass by fast pyrolysis, J. Anal. Appl. Pyrolysis, 5, 151, 10.1016/0165-2370(83)80021-7 · DOI
  129. Ruiz-Aquino, 2015, Chemical characterization and fuel properties of wood and bark of two oaks from Oaxaca, Mexico, Ind. Crop. Prod., 65, 90, 10.1016/j.indcrop.2014.11.024 · DOI · Paper page
  130. Saraeian, 2019, Deoxygenation of biomass pyrolysis vapors: improving clarity on the fate of carbon, Renew. Sust. Energ. Rev., 104, 262, 10.1016/j.rser.2019.01.037 · DOI
  131. Scott, 1999, A second look at fast pyrolysis of biomass—the RTI process, J. Anal. Appl. Pyrolysis, 51, 23, 10.1016/S0165-2370(99)00006-6 · DOI
  132. Serrano, 2013, Synthesis strategies in the search for hierarchical zeolites, Chem. Soc. Rev., 42, 4004, 10.1039/C2CS35330J · DOI
  133. Shadangi, 2014, Thermal and catalytic pyrolysis of Karanja seed to produce liquid fuel, Fuel, 115, 434, 10.1016/j.fuel.2013.07.053 · DOI
  134. Shafizadeh, 1979, Production of levoglucosan and glucose from pyrolysis of cellulosic materials, J. Appl. Polym. Sci., 23, 3525, 10.1002/app.1979.070231209 · DOI
  135. Shao, 2016, Enhancement of hydrocarbon production and catalyst stability during catalytic conversion of biomass pyrolysis-derived compounds over hierarchical HZSM-5, RSC Adv., 6, 44313, 10.1039/C6RA05356D · DOI
  136. Sharifzadeh, 2019, The multi-scale challenges of biomass fast pyrolysis and bio-oil upgrading: review of the state of art and future research directions, Progress Energy Combust. Sci., 71, 1, 10.1016/j.pecs.2018.10.006 · DOI
  137. Shen, 2009, The mechanism for thermal decomposition of cellulose and its main products, Bioresour. Technol., 100, 6496, 10.1016/j.biortech.2009.06.095 · DOI
  138. Shen, 2010, Study on the pyrolytic behaviour of xylan-based hemicellulose using TG–FTIR and Py–GC–FTIR, J. Anal. Appl. Pyrolysis, 87, 199, 10.1016/j.jaap.2009.12.001 · DOI
  139. Socci, 2019, The role of catalyst acidity and shape selectivity on products from the catalytic fast pyrolysis of beech wood, J. Anal. Appl. Pyrolysis
  140. Stefanidis, 2011, In-situ upgrading of biomass pyrolysis vapors: catalyst screening on a fixed bed reactor, Bioresour. Technol., 102, 8261, 10.1016/j.biortech.2011.06.032 · DOI
  141. Stocker, 2008, Biofuels and biomass-to-liquid fuels in the biorefinery: catalytic conversion of lignocellulosic biomass using porous materials, Angew. Chem. Int. Ed., 47, 9200, 10.1002/anie.200801476 · DOI
  142. Sui, 2012, Preparation of levoglucosenone through sulfuric acid promoted pyrolysis of bagasse at low temperature, Bioresour. Technol., 103, 466, 10.1016/j.biortech.2011.10.010 · DOI
  143. Sun, 2016, Comparision of catalytic fast pyrolysis of biomass to aromatic hydrocarbons over ZSM-5 and Fe/ZSM-5 catalysts, J. Anal. Appl. Pyrolysis, 121, 342, 10.1016/j.jaap.2016.08.015 · DOI
  144. Sweygers, 2020, Simultaneous production of 5-hydroxymethylfurfural and furfural from bamboo (Phyllostachys nigra “Boryana”) in a biphasic reaction system, Chem. Eng. J., 386, 10.1016/j.cej.2019.123957 · DOI
  145. Taarning, 2011, Zeolite-catalyzed biomass conversion to fuels and chemicals, Energy Environ. Sci., 4, 793, 10.1039/C004518G · DOI
  146. Taimoor, 2012, Upgrading of biomass transformation residue: influence of gas flow composition on acetic acid ketonic condensation, Catal. Sci. Technol., 2, 359, 10.1039/C1CY00346A · DOI
  147. To, 2014, Role of a phenolic pool in the conversion of m-cresol to aromatics over HY and HZSM-5 zeolites, Appl. Catal., A, 487, 62, 10.1016/j.apcata.2014.09.006 · DOI
  148. Torri, 2009, Analytical study on the production of a hydroxylactone from catalytic pyrolysis of carbohydrates with nanopowder aluminium titanate, J. Anal. Appl. Pyrolysis, 84, 25, 10.1016/j.jaap.2008.10.002 · DOI
  149. Varheyi, 1988, Simultaneous thermogravimetric-mass spectrometric studies of the thermal decomposition of biopolymers. 1. Avicel cellulose in the presence and absence of catalysts, Energy Fuel, 2, 267, 10.1021/ef00009a007 · DOI
  150. Venderbosch, 2015, A critical view on catalytic pyrolysis of biomass, ChemSusChem, 8, 1306, 10.1002/cssc.201500115 · DOI
  151. Venkatesan, 2018, Selective production of aromatic hydrocarbons from lignocellulosic biomass via catalytic fast-hydropyrolysis using W2C/γ-Al2O3, Catal. Commun., 110, 68, 10.1016/j.catcom.2018.03.011 · DOI
  152. Vorwerk, 2004, The role of plant cell wall polysaccharide composition in disease resistance, Trends Plant Sci., 9, 203, 10.1016/j.tplants.2004.02.005 · DOI
  153. Waliszewska, 2019, Changes in the chemical composition and the structure of cellulose and lignin in elm wood exposed to various forms of arsenic, Cellulose, 26, 6303, 10.1007/s10570-019-02511-z · DOI
  154. Wang, 2016, Catalytic fast pyrolysis of mushroom waste to upgraded bio-oil products via pre-coked modified HZSM-5 catalyst, Bioresour. Technol., 212, 6, 10.1016/j.biortech.2016.04.005 · DOI
  155. Wang, 2014, Catalytic pyrolysis of individual components of lignocellulosic biomass, Green Chem., 16, 727, 10.1039/C3GC41288A · DOI
  156. Wang, 2015, Pyrolysis behaviors of four O-acetyl-preserved hemicelluloses isolated from hardwoods and softwoods, Fuel, 150, 243, 10.1016/j.fuel.2015.02.045 · DOI
  157. Wang, 2017, Lignocellulosic biomass pyrolysis mechanism: a state-of-the-art review, Progress Energy Combust. Sci., 62, 33, 10.1016/j.pecs.2017.05.004 · DOI
  158. Wang, 2018, Catalytic pyrolysis of larch sawdust for phenol-rich bio-oil using different catalysts, Renew. Energy, 121, 146, 10.1016/j.renene.2018.01.018 · DOI
  159. Wang, 2019, Microwave-assisted catalytic pyrolysis of cellulose for phenol-rich bio-oil production, J. Energy Instit., 92, 1997, 10.1016/j.joei.2018.10.012 · DOI
  160. Wang, 2020, High efficiency pyrolysis of used cigarette filters for ester-rich bio-oil through microwave-assisted heating, J. Clean. Prod., 257, 10.1016/j.jclepro.2020.120596 · DOI
  161. Wang, 2011, Catalytic fast pyrolysis of cellulose to prepare levoglucosenone using sulfated zirconia, ChemSusChem, 4, 79, 10.1002/cssc.201000210 · DOI
  162. White, 2011, Methanol-to-hydrocarbon chemistry: the carbon pool (r)evolution, Catal. Sci. Technol., 1, 1630, 10.1039/c1cy00197c · DOI
  163. Williams, 2012, Cycloaddition of biomass-derived furans for catalytic production of renewable p-xylene, ACS Catal., 2, 935, 10.1021/cs300011a · DOI
  164. Xu, 2015, Direct production of indoles via thermo-catalytic conversion of bio-derived furans with ammonia over zeolites, Green Chem., 17, 1281, 10.1039/C4GC02250E · DOI
  165. Xu, 2015, Renewable N-heterocycles production by thermocatalytic conversion and ammonization of biomass over ZSM-5, ACS Sustain. Chem. Eng., 3, 2890, 10.1021/acssuschemeng.5b00841 · DOI
  166. Xu, 2017, Integrated production of aromatic amines and N-doped carbon from lignin via ex situ catalytic fast pyrolysis in the presence of ammonia over zeolites, ACS Sustain. Chem. Eng., 5, 2960, 10.1021/acssuschemeng.6b02542 · DOI
  167. Xue, 2016, Catalytic co-pyrolysis of biomass and polyethylene in a tandem micropyrolyzer, Fuel, 166, 227, 10.1016/j.fuel.2015.10.125 · DOI
  168. Yaman, 2018, Catalytic upgrading of pyrolysis vapours: effect of catalyst support and metal type on phenolic content of bio-oil, J. Clean. Prod., 185, 52, 10.1016/j.jclepro.2018.03.033 · DOI
  169. Yang, 2007, Characteristics of hemicellulose, cellulose and lignin pyrolysis, Fuel, 86, 1781, 10.1016/j.fuel.2006.12.013 · DOI · Paper page
  170. Yang, 2019, Unveiling the pyrolysis mechanisms of hemicellulose: experimental and theoretical studies, Energy Fuel, 33, 4352, 10.1021/acs.energyfuels.9b00482 · DOI
  171. Yang, 2018, Production of renewable alkyl-phenols from catalytic pyrolysis of Douglas fir sawdust over biomass-derived activated carbons, Appl. Energy, 220, 426, 10.1016/j.apenergy.2018.03.107 · DOI
  172. Yao, 2015, Production of indoles via thermo-catalytic conversion and ammonization of bio-derived furfural, Chem. Eng. J., 280, 74, 10.1016/j.cej.2015.05.094 · DOI
  173. Yao, 2016, Enhancement of indoles production and catalyst stability in thermo-catalytic conversion and ammonization of furfural with NH3 and N2 environments, J. Anal. Appl. Pyrolysis, 121, 258, 10.1016/j.jaap.2016.08.005 · DOI
  174. Yao, 2017, Selective production of pyrroles via catalytic fast pyrolysis of cellulose under ammonia atmosphere at low temperature, J. Anal. Appl. Pyrolysis, 124, 409, 10.1016/j.jaap.2017.03.004 · DOI
  175. Yildiz, 2015, Effect of biomass ash in catalytic fast pyrolysis of pine wood, Appl. Catal., B, 168-169, 203, 10.1016/j.apcatb.2014.12.044 · DOI
  176. Yu, 2020, Chemicals from lignocellulosic biomass: a critical comparison between biochemical, microwave and thermochemical conversion methods, Crit. Rev. Environ. Sci. Technol., 1
  177. Yu, 2012, The role of shape selectivity in catalytic fast pyrolysis of lignin with zeolite catalysts, Appl. Catal., A, 447-448, 115, 10.1016/j.apcata.2012.09.012 · DOI
  178. Zhang, 2014, Catalytic upgrading of corn stalk fast pyrolysis vapors with fresh and hydrothermally treated HZSM-5 catalysts using Py-GC/MS, Ind. Eng. Chem. Res., 53, 9979, 10.1021/ie404426x · DOI
  179. Zhang, 2015, Catalytic upgrading of fast pyrolysis biomass vapors over fresh, spent and regenerated ZSM-5 zeolites, Fuel Process. Technol., 138, 430, 10.1016/j.fuproc.2015.06.011 · DOI
  180. Zhang, 2009, Comparison of non-catalytic and catalytic fast pyrolysis of corncob in a fluidized bed reactor, Bioresour. Technol., 100, 1428, 10.1016/j.biortech.2008.08.031 · DOI
  181. Zhang, 2011, Catalytic conversion of biomass-derived feedstocks into olefins and aromatics with ZSM-5: the hydrogen to carbon effective ratio, Energy Environ. Sci., 4, 2297, 10.1039/c1ee01230d · DOI
  182. Zhang, 2012, Catalytic fast pyrolysis of wood and alcohol mixtures in a fluidized bed reactor, Green Chem., 14, 98, 10.1039/C1GC15619E · DOI
  183. Zhang, 2013, Catalytic fast pyrolysis of straw biomass in an internally interconnected fluidized bed to produce aromatics and olefins: effect of different catalysts, Bioresour. Technol., 137, 82, 10.1016/j.biortech.2013.03.031 · DOI
  184. Zhang, 2007, Review of biomass pyrolysis oil properties and upgrading research, Energy Convers. Manag., 48, 87, 10.1016/j.enconman.2006.05.010 · DOI
  185. Zhang, 2013, Levoglucosan formation mechanisms during cellulose pyrolysis, J. Anal. Appl. Pyrolysis, 104, 19, 10.1016/j.jaap.2013.09.015 · DOI
  186. Zhang, 2015, Renewable gasoline-range aromatics and hydrogen-enriched fuel gas from biomass via catalytic microwave-induced pyrolysis, Green Chem., 17, 4029, 10.1039/C5GC00516G · DOI
  187. Zhang, 2016, Catalytic co-pyrolysis of lignocellulosic biomass with polymers: a critical review, Green Chem., 18, 4145, 10.1039/C6GC00911E · DOI · Paper page
  188. Zhang, 2019, Catalytic fast pyrolysis of corn cob in ammonia with Ga/HZSM-5 catalyst for selective production of acetonitrile, Bioresour. Technol., 290, 10.1016/j.biortech.2019.121800 · DOI
  189. Zhang, 2018, From glucose-based carbohydrates to phenol-rich bio-oils integrated with syngas production via catalytic pyrolysis over an activated carbon catalyst, Green Chem., 20, 3346, 10.1039/C8GC00593A · DOI
  190. Zhang, 2018, Renewable high-purity mono-phenol production from catalytic microwave-induced pyrolysis of cellulose over biomass-derived activated carbon catalyst, ACS Sustain. Chem. Eng., 6, 5349, 10.1021/acssuschemeng.8b00129 · DOI
  191. Zhang, 2019, Direct conversion of cellulose and raw biomass to acetonitrile by catalytic fast pyrolysis in ammonia, Green Chem., 21, 812, 10.1039/C8GC03354D · DOI
  192. Zhang, 2019, Fast pyrolysis of biomass catalyzed by magnetic solid base catalyst in a hydrogen atmosphere for selective production of phenol, Ind. Crops Products, 137, 495, 10.1016/j.indcrop.2019.05.066 · DOI
  193. Zheng, 2016, Initial reaction mechanisms of cellulose pyrolysis revealed by ReaxFF molecular dynamics, Fuel, 177, 130, 10.1016/j.fuel.2016.03.008 · DOI
  194. Zheng, 2019, Integrated production of aromatic amines, aromatic hydrocarbon and N-heterocyclic bio-char from catalytic pyrolysis of biomass impregnated with ammonia sources over Zn/HZSM-5 catalyst, J. Energy Inst., 93, 210
  195. Zhou, 2011, Catalytic conversion of lignocellulosic biomass to fine chemicals and fuels, Chem. Soc. Rev., 40, 5588, 10.1039/c1cs15124j · DOI · Paper page
  196. Zhou, 2020, Syngas production from biomass pyrolysis in a continuous microwave assisted pyrolysis system, Bioresour. Technol., 314, 10.1016/j.biortech.2020.123756 · DOI

Cited by

Sorted by citations

Metadata

Authors
Dai, L., Wang, Y., Liu, Y., He, C., Ruan, R., Yu, Z., Jiang, L., Zeng, Z., & Wu, Q.
Affiliations
  • Nanchang University (CN)
  • Sun Yat-sen University (CN)
  • University of Minnesota (US)
Corresponding author
  • Wang, Yunpu
  • Liu, Yuhuan
  • He, Chao
ORCID
Venue
Science of The Total Environment
Publisher
Elsevier BV
Published
2020-12
Volume
749
Pages
142386
ISSN
0048-9697 (ISSN-L)
DOI
10.1016/j.scitotenv.2020.142386
OpenAlex
W3087641242
Cited by
264
References
9
Citations by year
2026: 16 · 2025: 41 · 2024: 50 · 2023: 41 · 2022: 71 · 2021: 43 · 2020: 2
FWCI
3.28
Type
journal article
Language
en
Open access
closed
Licence
Locations
  • The Science of The Total Environment (publishedVersion)
  • PubMed (publishedVersion)
Funders
  • National Natural Science Foundation of China (21766019, 21878137)
  • Natural Science Foundation of Jiangxi Province (20181BAB206030)
  • China Scholarship Council
Topics
  • Physical Sciences › Energy › Fuel Technology › Thermochemical Biomass Conversion Processes
  • Physical Sciences › Chemical Engineering › Catalysis › Catalysis for Biomass Conversion
  • Physical Sciences › Chemistry › Inorganic Chemistry › Zeolite Catalysis and Synthesis
Keywords
catalytic pyrolysis, lignocellulosic biomass, value-added chemicals, bio-oil upgrading, zeolites, metal oxides, phenols, anhydro sugars, nitrogen compounds, Diels-Alder reaction, aromatization, ketonization, aldol condensation, ammoniation, crack formation, renewable chemicals
MeSH terms
Pyrolysis, Catalysis, Hot Temperature, Lignin, Biomass, Biofuels

About these checks

Registry, retraction, Cites and statistics results are computed, not judged, with one exception: a printed reference that no index lists is read once by a model before it counts as a citation error. Claims are extracted by a model and kept only when their quote appears verbatim in the text; each cited source is then checked, with a model’s help, for whether it says what the claim relies on. Those verdicts can be wrong — read the claim’s quote and the cited source before relying on one.

Statistics and arithmetic are recomputed, not judged.

Confidence bands are shown only for fields calibrated on our annotated test set. None is calibrated yet, so no band is shown.

What counts as a claim ›How we measure confidence ›How we check this ›

Are you an author, or do you see a problem with this page? Request a review