The DOI matches its Crossref record; 32 of the 32 references it cites were found in a registry or an index.
Lyophobicity and slagging resistance mechanism of h-BN based coating for coal-fired boilers
Abstract
Abstract Sodium reacts with sulfur oxide to form molten Na2SO4 during combustion of high-sodium coal (HSC). The resulting sticky inner layer captures ash to form slag, which inhibits heat transfer and flow of combustion gases. A novel water-based ceramic coating with hexagonal boron nitride (h-BN) as the main component has been recently developed to address the slagging problem in boilers that burn HSC. In the present study, wettability tests were performed to show that, compared with uncoated steel, the coating was completely lyophobic to molten Na2SO4. Density functional theory was used to study the adsorption of Na2SO4 on coated and uncoated steel at the atomic level. The calculated adsorption energies, electronic density of states, and Bader charges of Na atoms adsorbed on h-BN(0001) and Fe2O3(110), representing the coating and steel, respectively, indicated that the interaction of Na atoms with h-BN(0001) is significantly weaker than that with Fe2O3(110). Therefore, the ceramic coating could effectively inhibit the formation of the sticky inner layer composed mainly of Na2SO4 and alleviate the slagging of HSC-fired boilers.
Overview
Integrity signals
Registry
Cites
Statistics
Verification
Claims the paper makes
Claims other papers make about this one
Each is checked against this paper’s own text: does it say what the citing paper says it does?
In the citing paper
“The slag reduction by coatings is contributed by two mechanisms, which are (I) prevention of high temperature corrosion from slag deposits [144, 149, 150] and (II) reducing the wettability of molten fly ash on the coated surfaces [145, 147].”
From High Temperature Corrosion Resistant and Anti-slagging Coatings for Boilers: A Review (2024) · cites this paper as [147]
In the citing paper
“The coated surface reduced the wettability of Na2SO4, resulting in a weakened ability of the initial sticky layer to capture fly ash particles and restrict the further formation of the slag deposits.”
From High Temperature Corrosion Resistant and Anti-slagging Coatings for Boilers: A Review (2024) · cites this paper as [147]
In the citing paper
“The lyophobicity of such coatings was reflected by poor wettability of molten Na2SO4 droplets—an alkali salt to form the initial sticky layer—on the coated surface compared to uncoated metal.”
From High Temperature Corrosion Resistant and Anti-slagging Coatings for Boilers: A Review (2024) · cites this paper as [147]
Citations
Cites
Perdew, J. P., Chevary, J. A., Vosko, S. H., Jackson, K. A., Pederson, M. R., Singh, D. J., & Fiolhais, C. (1992) · Physical Review B · doi:10.1103/physrevb.46.6671 · Cited by 22,269
Perdew, J. P., Chevary, J. A., Vosko, S. H., Jackson, K. A., Pederson, M. R., Singh, D. J., & Fiolhais, C. (1993) · Physical Review B · doi:10.1103/physrevb.48.4978.2 · Cited by 17,144
Unified Approach for Molecular Dynamics and Density-Functional Theory
Car, R., & Parrinello, M. (1985) · Physical Review Letters · doi:10.1103/physrevlett.55.2471 · Cited by 10,754
A quantum theory of molecular structure and its applications
Bader, R. F. W. (1991) · Chemical Reviews · doi:10.1021/cr00005a013 · Cited by 7,306
Perdew, Burke, and Ernzerhof Reply:
Perdew, J. P., Burke, K., & Ernzerhof, M. (1998) · Physical Review Letters · doi:10.1103/physrevlett.80.891 · Cited by 1,690
On the properties of washed straw
Jenkins, B. M., Bakker, R. R. C., & Wei, J. (1996) · Biomass and Bioenergy · doi:10.1016/0961-9534(95)00058-5 · Cited by 383
Wang, X., Xu, Z., Wei, B., Zhang, L., Tan, H., Yang, T., Mikulčić, H., & Duić, N. (2015) · Applied Thermal Engineering · doi:10.1016/j.applthermaleng.2015.01.051 · Cited by 314
Cai, Y., Tay, K., Zheng, Z., Yang, W., Wang, H., Zeng, G., Li, Z., Siah, K. B., & Subbaiah, P. (2018) · Applied Energy · doi:10.1016/j.apenergy.2018.08.084 · Cited by 203
Tran, K., Iisa, K., Steenari, B., & Lindqvist, O. (2004) · Fuel · doi:10.1016/j.fuel.2004.08.019 · Cited by 140
Wu, L., Xiao, J., Wu, Y., Xian, S., Miao, G., Wang, H., & Li, Z. (2014) · Langmuir · doi:10.1021/la404540j · Cited by 139
A computational study of Na behavior on graphene
Malyi, O. I., Sopiha, K. V., Kulish, V. V., Tan, T. L., Manzhos, S., & Persson, C. (2015) · Applied Surface Science · doi:10.1016/j.apsusc.2015.01.236 · Cited by 115
Chen, X., Kong, L., Bai, J. F., Dai, X., Li, H., Bai, Z., & Li, W. (2017) · Applied Energy · doi:10.1016/j.apenergy.2017.10.020 · Cited by 112
Wei, J., Sun, W., Pan, W., Yu, X., Sun, G., & Jiang, H. Y. (2016) · Chemical Engineering Journal · doi:10.1016/j.cej.2016.11.133 · Cited by 104
Li, J., Zhu, M., Zhang, Z., Zhang, K., Shen, G., & Zhang, D. (2016) · Fuel Processing Technology · doi:10.1016/j.fuproc.2016.04.021 · Cited by 80
Lithium and sodium adsorption properties of two-dimensional aluminum nitride
Sengupta, A. (2018) · Applied Surface Science · doi:10.1016/j.apsusc.2018.04.264 · Cited by 76
Wu, H., Bashir, M. S., Jensen, P. A., Sander, B., & Glarborg, P. (2013) · Fuel · doi:10.1016/j.fuel.2013.06.018 · Cited by 74
Barroso, J., Ballester, J. M., Ferrer, L. M., & Jiménez, S. (2006) · Fuel Processing Technology · doi:10.1016/j.fuproc.2006.02.004 · Cited by 67
Removal of Gaseous Alkali Metal Compounds from Hot Flue Gas by Particulate Sorbents
Lee, S. H. D., & Johnson, I. (1980) · Journal of Engineering for Power · doi:10.1115/1.3230269 · Cited by 66
Control of ash deposition in pulverized coal fired boiler
Naganuma, H., Ikeda, N., Kawai, T., Takuwa, T., Ito, T., Igarashi, Y., Yoshiie, R., & Naruse, I. (2008) · Proceedings of the Combustion Institute · doi:10.1016/j.proci.2008.06.001 · Cited by 52
New generation of protective coatings intended for the power industry
Formanek, B., Szymański, K., Szczucka-Lasota, B., & Włodarczyk, A. (2005) · Journal of Materials Processing Technology · doi:10.1016/j.jmatprotec.2005.02.098 · Cited by 42
Theoretical investigation of sodium capture mechanism on kaolinite surfaces
Zhang, Z., Liu, J., Yang, Y., Shen, F., & Zhang, Z. (2018) · Fuel · doi:10.1016/j.fuel.2018.07.042 · Cited by 40
Reduction mechanisms of ash deposition in coal and/or biomass combustion boilers
Naganuma, H., Ikeda, N., Ito, T., Matsuura, M., Nunome, Y., Ueki, Y., Yoshiie, R., & Naruse, I. (2013) · Fuel · doi:10.1016/j.fuel.2012.11.017 · Cited by 38
Control of ash deposition in solid fuel fired boiler
Naganuma, H., Ikeda, N., Ito, T., Satake, H., Matsuura, M., Ueki, Y., Yoshiie, R., & Naruse, I. (2013) · Fuel Processing Technology · doi:10.1016/j.fuproc.2011.09.009 · Cited by 34
Bläsing, M., & Müller, M. R. (2013) · Combustion and Flame · doi:10.1016/j.combustflame.2013.08.005 · Cited by 29
High-temperature sulfur corrosion behavior of h-BN-based ceramic coating prepared by slurry method
Wang, J., Yuan, Y., Chi, Z., et al. (2017) · Materials Chemistry and Physics · doi:10.1016/j.matchemphys.2017.12.025 · Cited by 28
Self-citationDevelopment and application of anti-fouling ceramic coating for high-sodium coal-fired boilers
Wang, J., Yuan, Y., Chi, Z., & Zhang, G. (2018) · Journal of the Energy Institute · doi:10.1016/j.joei.2017.08.003 · Cited by 27
Self-citationChen, J., Ninomiya, Y., Naganuma, H., Sasaki, Y., Noguchi, M., Cho, H., Ueki, Y., Yoshiie, R., & Naruse, I. (2015) · Fuel Processing Technology · doi:10.1016/j.fuproc.2015.08.040 · Cited by 26
Shan, X., Wei, L., Zhang, X. M., Li, W. H., Tang, W., Liu, Y., Tong, J., Ye, S. F., & Chen, Y. F. (2014) · Ceramics International · doi:10.1016/j.ceramint.2014.12.019 · Cited by 25
Atomic and molecular adsorption on RhMn alloy surface: A first principles study
Ma, X., Deng, H., Yang, M., & Li, W. (2008) · The Journal of Chemical Physics · doi:10.1063/1.3046691 · Cited by 16
Local effect of Na adsorption on Cu(111)
Yu, S., Bahrim, B., Makarenko, B. N., & Rabalais, J. W. (2012) · Surface Science · doi:10.1016/j.susc.2012.07.012 · Cited by 14
Na adsorption on SrTiO3 (0 0 1) surface and its interaction with water: A DFT calculation
Wang, J., Li, Z., & Zou, Z. (2013) · Applied Surface Science · doi:10.1016/j.apsusc.2013.01.030 · Cited by 7
Self-citationWang, X., Wu, H., Deng, S., Zhang, L., Wei, B., & Tan, H. (2016) · Springer eBooks · doi:10.1007/978-981-10-2023-0_14 · Cited by 6
Research works printed but not linked: 1
- Zhang, 2013, Situation of combustion utilization of high sodium coal, vol. 33, 1
Cited by
High Temperature Corrosion Resistant and Anti-slagging Coatings for Boilers: A Review
Khantisopon, K., Singh, S., Jitputti, J., Berndt, C. C., & Ang, A. S. M. (2024) · High Temperature Corrosion of Materials · doi:10.1007/s11085-024-10251-0 · Cited by 30
Slagging resistance mechanism of precursor ceramic coating for solid fuel-fired boilers
Wang, G., Zhang, B., Wang, J., Chi, Z., Zhang, G., li, J., Wang, J., Qian, P., & Yang, S. (2020) · IOP Conference Series: Materials Science and Engineering · doi:10.1088/1757-899x/721/1/012023 · Cited by 3
Self-citation
Metadata
- Authors
- Wang, J., Zhang, G., Li, F., & Chi, Z.
- Affiliations
- China Jiliang University (CN)
- Corresponding author
- Wang, Jinqing
- Venue
- Fuel Processing Technology
- Publisher
- Elsevier BV
- Published
- 2019-06
- Volume
- 188
- Pages
- 43-50
- ISSN
- 0378-3820 (ISSN-L)
- OpenAlex
- W2912334715
- Cited by
- 15
- References
- 32
- Citations by year
- 2026: 1 · 2025: 2 · 2024: 5 · 2023: 1 · 2022: 4 · 2020: 1 · 2019: 1
- FWCI
- 1.10
- Type
- journal article
- Language
- en
- Open access
- closed
- Licence
- www.elsevier.com/tdm/userlicense/1.0/ (tdm)
- Locations
- Fuel Processing Technology (publishedVersion)
- Funders
- National Natural Science Foundation of China (51876197)
- Public Projects of Zhejiang Province (2017C31043)
- Department of Education of Zhejiang Province (Y201534242)
- Topics
- Physical Sciences › Materials Science › Surfaces, Coatings and Films › High-Temperature Coating Behaviors
- Physical Sciences › Engineering › Mechanical Engineering › Coal Combustion and Slurry Processing
- Physical Sciences › Earth and Planetary Sciences › Geochemistry and Petrology › Coal and Its By-products
- Keywords
- hexagonal boron nitride, ceramic coatings, slagging, high-sodium coal, coal-fired boilers, wettability, adsorption energy, Fe2O3, Bader charge, density functional theory, waterborne coatings
About these checks
Registry, retraction, Cites and statistics results are computed, not judged, with one exception: a printed reference that no index lists is read once by a model before it counts as a citation error. Claims are extracted by a model and kept only when their quote appears verbatim in the text; each cited source is then checked, with a model’s help, for whether it says what the claim relies on. Those verdicts can be wrong — read the claim’s quote and the cited source before relying on one.
Statistics and arithmetic are recomputed, not judged.
Confidence bands are shown only for fields calibrated on our annotated test set. None is calibrated yet, so no band is shown.
What counts as a claim ›How we measure confidence ›How we check this ›
Are you an author, or do you see a problem with this page? Request a review
Data sources
Bibliographic data: Semantic Scholar, OpenAlex, Crossref.
Contains information from the Semantic Scholar Academic Graph Datasets, made available under the ODC Attribution License (ODC-BY 1.0).
Semantic Scholar’s data is described in: Kinney, R., et al. (2023). The Semantic Scholar Open Data Platform. arXiv:2301.10140.
