Production of Bio-Coal, Bio-Methane and Fertilizer from Seaweed via Hydrothermal Carbonisation
Open accessAbstract
Macroalgae have emerged as a potential future source of feedstock for the production of chemicals and biofuels. The main drawbacks of macroalgae in terms of a biofuel feedstock are its low heating value (HHV), high halogen content, high ash content and high slagging and fouling propensity. In this investigation, three species of kelps; (i) Laminaria digitata (ii) Laminaria hyperborea and (iii) Alaria esculenta have been processed by hydrothermal carbonisation (HTC) in a batch reactor at two temperatures (200 °C and 250 °C). The yields and properties of the resulting hydrochars including their HHV, CHNS, mineral content and ash fusibility properties have been determined and compared to the starting material. Significant improvement in fuel quality is observed resulting in an increase in energy density from 10 MJ/kg to typically 25 MJ/kg, which is comparable to that of a low rank coal. The results indicate significant demineralisation of the fuel, in particular a significant removal of alkali salts and chlorine. This results in improved combustion properties due to a reduction in the slagging and fouling properties of the fuel. Analysis of the HTC water phase indicates the presence of high levels of soluble organic carbon consisting of sugars and organic acids, and high levels of potassium, magnesium and phosphorous. The potential for production of bio-methane and recovery of nutrients following anaerobic treatment of the water phase is assessed. A prediction of the bio-methane yields for the different seaweeds has been calculated. Processing of biomass collected throughout the growth season indicates the influence of seasonal variation on energy and nutrient recovery.
The claims and statistics of this paper haven’t been checked yet.
Run the check — free, no account needed. It reads the open-access text and checks the sources it cites.
Integrity signals
Registry
Cites
Statistics
Claims the paper makes
The claims and statistics of this paper haven’t been checked yet.
Run the check — free, no account needed. It reads the open-access text and checks the sources it cites.
Claims other papers make about this one
Each is checked against this paper’s own text: does it say what the citing paper says it does?
Algae-based biocoal is produced through pyrolysis and carbonization of algal biomass at high temperatures under anaerobic conditions.
“Algae-based biocoal is produced through the pyrolysis and carbonization of algal biomass at specific high temperatures under anaerobic conditions [173,174].”
From A Review of Algae-Based Carbon Capture, Utilization, and Storage (Algae-Based CCUS) (2024) · cites this paper as [173]
Self-check
Percentages, sums and reported differences re-computed from the paper’s own numbers.
The self-check needs the paper’s full text.
Cites
Funke, A., & Ziegler, F. (2010) · Biofuels Bioproducts and Biorefining · doi:10.1002/bbb.198 · Cited by 2,001 · see citing works
Combustion properties of biomass
Jenkins, B. M., Baxter, L. L., Miles, T. R., & Miles, T. R. (1998) · Fuel Processing Technology · doi:10.1016/s0378-3820(97)00059-3 · Cited by 1,948 · see citing works
Libra, J. A., Ro, K. S., Kammann, C., Funke, A., Berge, N. D., Neubauer, Y., Titirici, M.-M., Fühner, C., Bens, O., Kern, J., et al. (2011) · Biofuels · doi:10.4155/bfs.10.81 · Cited by 1,756 · see citing works
The Handbook of Biomass Combustion and Co-firing
(2012) · doi:10.4324/9781849773041 · Cited by 1,423 · see citing works
A critical review on inhibition of anaerobic digestion process by excess ammonia
Rajagopal, R., Massé, D. I., & Singh, G. (2013) · Bioresource Technology · doi:10.1016/j.biortech.2013.06.030 · Cited by 1,307 · see citing works
Biller, P., & Ross, A. B. (2011) · Bioresource Technology · doi:10.1016/j.biortech.2010.06.028 · Cited by 1,131 · see citing works
Self-citationWaste to bioproduct conversion with undefined mixed cultures: the carboxylate platform
Agler, M. T., Wrenn, B. A., Zinder, S. H., & Angenent, L. T. (2010) · Trends in biotechnology · doi:10.1016/j.tibtech.2010.11.006 · Cited by 821 · see citing works
Hydrothermal Carbonization (HTC) of Lignocellulosic Biomass
Hoekman, S. K., Broch, A., & Robbins, C. (2011) · Energy & Fuels · doi:10.1021/ef101745n · Cited by 722 · see citing works
Classification of macroalgae as fuel and its thermochemical behaviour
Ross, A. B., Jones, J. M., Kubacki, M. L., & Bridgeman, T. (2008) · Bioresource Technology · doi:10.1016/j.biortech.2007.11.036 · Cited by 643 · see citing works
Self-citationSchiener, P., Black, K. D., Stanley, M. S., & Green, D. H. (2015) · Journal of Applied Phycology · doi:10.1007/s10811-014-0327-1 · Cited by 571 · see citing works
Titirici, M., Thomas, A., Yu, S., Müller, J., & Antonietti, M. (2007) · Chemistry of Materials · doi:10.1021/cm0707408 · Cited by 535 · see citing works
Anastasakis, K., & Ross, A. B. (2011) · Bioresource Technology · doi:10.1016/j.biortech.2011.01.031 · Cited by 490 · see citing works
Self-citationPotentials of macroalgae as feedstocks for biorefinery
Jung, K. A., Lim, S.-R., Kim, Y., & Park, J. M. (2013) · Bioresource Technology · doi:10.1016/j.biortech.2012.10.025 · Cited by 487 · see citing works
Baccile, N., Laurent, G. P., Babonneau, F., Fayon, F., Titirici, M., & Antonietti, M. (2009) · The Journal of Physical Chemistry C · doi:10.1021/jp901582x · Cited by 477 · see citing works
Use of macroalgae for marine biomass production and CO2 remediation: a review
Gao, K., & McKinley, K. R. (1994) · Journal of Applied Phycology · doi:10.1007/bf02185904 · Cited by 402 · see citing works
Adams, J. M. M., Gallagher, J. A., & Donnison, I. S. (2008) · Journal of Applied Phycology · doi:10.1007/s10811-008-9384-7 · Cited by 363 · see citing works
Smith, A. M., Singh, S., & Ross, A. B. (2015) · Fuel · doi:10.1016/j.fuel.2015.12.006 · Cited by 360 · see citing works
Self-citationDanso-Boateng, E., Shama, G., Wheatley, A. D., Martin, S. J., & Holdich, R. G. (2015) · Bioresource Technology · doi:10.1016/j.biortech.2014.11.096 · Cited by 353 · see citing works
Ethanol production from seaweed extract
Horn, S. J., Aasen, I. M., & �stgaard, K. (2000) · Journal of Industrial Microbiology & Biotechnology · doi:10.1038/sj.jim.7000065 · Cited by 310 · see citing works
The characteristics of bio-oil produced from the pyrolysis of three marine macroalgae
Bae, Y. J., Ryu, C., Jeon, J., Park, J., Suh, D. J., Suh, Y., Chang, D., & Park, Y.-K. (2010) · Bioresource Technology · doi:10.1016/j.biortech.2010.11.023 · Cited by 289 · see citing works
Acetic acid and lithium chloride effects on hydrothermal carbonization of lignocellulosic biomass
Lynam, J. G., Coronella, C. J., Yan, W., Reza, M. T., & Vasquez, V. R. (2011) · Bioresource Technology · doi:10.1016/j.biortech.2011.02.035 · Cited by 260 · see citing works
Adams, J. M. M., Ross, A. B., Anastasakis, K., Hodgson, E., Gallagher, J. A., Jones, J. M., & Donnison, I. S. (2010) · Bioresource Technology · doi:10.1016/j.biortech.2010.06.152 · Cited by 242 · see citing works
Self-citationThe seasonal variation in weight and chemical composition of the common British Laminariaceae
Black, W. A. P. (1950) · Journal of the Marine Biological Association of the United Kingdom · doi:10.1017/s0025315400056186 · Cited by 226 · see citing works
Ross, A. B., Anastasakis, K., Kubacki, M. L., & Jones, J. M. (2008) · Journal of Analytical and Applied Pyrolysis · doi:10.1016/j.jaap.2008.11.004 · Cited by 208 · see citing works
Self-citationBiogas from Macroalgae: is it time to revisit the idea?
Hughes, A. D., Kelly, M. S., Black, K., & Stanley, M. S. (2012) · Biotechnology for Biofuels · doi:10.1186/1754-6834-5-86 · Cited by 198 · see citing works
Grimm, A., Skoglund, N., Boström, D., et al. (2011) · Energy & Fuels · doi:10.1021/ef101451e · Cited by 190 · see citing works
Hydrothermal carbonization of distiller’s grains
Heilmann, S. M., Jader, L. R., Sadowsky, M. J., Schendel, F. J., von Keitz, M. G., & Valentas, K. J. (2011) · Biomass and Bioenergy · doi:10.1016/j.biombioe.2011.02.022 · Cited by 172 · see citing works
Xu, Q., Qian, Q., Quek, A., Ai, N., Zeng, G., & Wang, J. (2013) · ACS Sustainable Chemistry & Engineering · doi:10.1021/sc400118f · Cited by 167 · see citing works
Hatcher, P. G., Breger, I. A., Szeverenyi, N. M., et al. (1982) · Organic Geochemistry · doi:10.1016/0146-6380(82)90003-1 · Cited by 156 · see citing works
Anastasakis, K., & Ross, A. B. (2014) · Fuel · doi:10.1016/j.fuel.2014.09.006 · Cited by 141 · see citing works
Self-citationAnaerobic Digestion of Waste Water from Hydrothermal Carbonization of Corn Silage
Wirth, B., & Mumme, J. (2013) · Applied Bioenergy · doi:10.2478/apbi-2013-0001 · Cited by 139 · see citing works
Suitability of hydrothermal liquefaction as a conversion route to produce biofuels from macroalgae
Barreiro, D. L., Beck, M., Hornung, U., Ronsse, F., Kruse, A., & Prins, W. (2015) · Algal Research · doi:10.1016/j.algal.2015.06.023 · Cited by 117 · see citing works
Effect of salt addition on hydrothermal carbonization of lignocellulosic biomass
Lynam, J. G., Reza, M. T., Vásquez, V. R., & Coronella, C. J. (2012) · Fuel · doi:10.1016/j.fuel.2012.04.035 · Cited by 109 · see citing works
Rowbotham, J. S., Dyer, P. W., Greenwell, H. C., & Theodorou, M. K. (2012) · Biofuels · doi:10.4155/bfs.12.29 · Cited by 88 · see citing works
Evaluation of marine biomass as a source of methane in batch tests: A lab-scale study
Gurung, A., Ginkel, S. W. V., Kang, W., Qambrani, N. A., & Oh, S. (2012) · Energy · doi:10.1016/j.energy.2012.04.005 · Cited by 77 · see citing works
Horn, S. J. (2000) · BIBSYS Brage (BIBSYS (Norway)) · Cited by 59 · see citing works
Cherad, R., Onwudili, J. A., Williams, P. T., & Ross, A. B. (2014) · Bioresource Technology · doi:10.1016/j.biortech.2014.07.046 · Cited by 55 · see citing works
Self-citationCorrosion in fire tube boilers of biomass combustion plants
Riedl-Narentenau, R., Dahl, J., Obernberger, I., et al. (1999) · Cited by 40 · see citing works
Jeon, W., Ban, C., Park, G., et al. (2015) · Journal of Molecular Catalysis A Chemical · doi:10.1016/j.molcata.2015.01.011 · Cited by 38 · see citing works
Chen, J., Chen, Z., Wang, C., et al. (2011) · Materials Letters · doi:10.1016/j.matlet.2011.10.017 · Cited by 29 · see citing works
Flagged first, then by citations
Cited by
Sorted by citations
Lee, X. J., Ong, H. C., Gan, Y. Y., Chen, W.-H., & Mahlia, T. M. I. (2020) · Energy Conversion and Management · doi:10.1016/j.enconman.2020.112707 · Cited by 465 · see citing works
Recent developments on algal biochar production and characterization
Yu, K. L., Lau, B. F., Show, P. L., Ong, H. C., Ling, T. C., Chen, W.-H., Ng, E. P., & Chang, J.-S. (2017) · Bioresource Technology · doi:10.1016/j.biortech.2017.08.009 · Cited by 425 · see citing works
Sustainable harvesting of wild seaweed resources.
Mac Monagail, M., Cornish, L., Morrison, L., Araújo, R., & Critchley, A. T. (2017) · European Journal of Phycology · doi:10.1080/09670262.2017.1365273 · Cited by 253 · see citing works
Munir, M. T., Mansouri, S. S., Udugama, I. A., Baroutian, S., Gernaey, K. V., & Young, B. R. (2018) · Renewable and Sustainable Energy Reviews · doi:10.1016/j.rser.2018.07.039 · Cited by 183 · see citing works
Wet organic waste treatment via hydrothermal processing: A critical review
Marzbali, M. H., Kundu, S., Halder, P., Patel, S., Hakeem, I. G., Paz-Ferreiro, J., Madapusi, S., Surapaneni, A., & Shah, K. (2021) · Chemosphere · doi:10.1016/j.chemosphere.2021.130557 · Cited by 147 · see citing works
Merzari, F., Langone, M., Andreottola, G., & Fiori, L. (2019) · Critical Reviews in Environmental Science and Technology · doi:10.1080/10643389.2018.1561104 · Cited by 115 · see citing works
A Review of Algae-Based Carbon Capture, Utilization, and Storage (Algae-Based CCUS)
Li, G., & Yao, J. (2024) · Gases · doi:10.3390/gases4040024 · Cited by 80 · see citing works
Cardona, S., Gallego, L. J., Valencia, V., Martínez, E., & Rios, L. A. (2019) · Sustainable Energy Technologies and Assessments · doi:10.1016/j.seta.2018.11.002 · Cited by 66 · see citing works
Valorisation of macroalgae via the integration of hydrothermal carbonisation and anaerobic digestion
Brown, A. E., Finnerty, G. L., Camargo-Valero, M. A., & Ross, A. B. (2020) · Bioresource Technology · doi:10.1016/j.biortech.2020.123539 · Cited by 64 · see citing works
Self-citation
- Authors
- Smith, A. M., & Ross, A. B.
- Affiliations
- University of Leeds (GB)
- Corresponding author
- Ross, Andrew B.
- ORCID
- Smith, Aidan M.
- Venue
- Algal Research
- Publisher
- Elsevier BV
- Published
- 2016-06
- Volume
- 16
- Pages
- 1-11
- ISSN
- 2211-9264 (ISSN-L)
- OpenAlex
- W2288741980
- Cited by
- 142
- References
- 40
- Citations by year
- 2026: 7 · 2025: 12 · 2024: 8 · 2023: 11 · 2022: 21 · 2021: 23 · 2020: 18 · 2019: 14 · 2018: 14 · 2017: 12 · 2016: 2
- FWCI
- 6.74
- Type
- journal article
- Language
- en
- Open access
- hybrid
- doi.org
- Locations
- Algal Research (publishedVersion, cc-by)
- White Rose Research Online (University of Leeds, The University of Sheffield, University of York) (acceptedVersion)
- Funders
- EPSRC (EP/G036608/1)
- European Commission (320J)
- Topics
- Physical Sciences › Engineering › Biomedical Engineering › Thermochemical Biomass Conversion Processes
- Physical Sciences › Energy › Renewable Energy, Sustainability and the Environment › Algal biology and biofuel production
- Life Sciences › Agricultural and Biological Sciences › Aquatic Science › Seaweed-derived Bioactive Compounds
- Keywords
- hydrothermal carbonization, seaweed, kelp, Laminaria digitata, Laminaria hyperborea, Alaria esculenta, hydrochar, bio-coal, biomethane, nutrient recovery, demineralization, ash fusibility, slagging and fouling, calorific value, anaerobic digestion, seasonal variation, biofuel feedstock
About these checks
Registry, retraction, Cites and statistics results are computed, not judged, with one exception: a printed reference that no index lists is read once by a model before it counts as a citation error. Claims are extracted by a model and kept only when their quote appears verbatim in the text; each cited source is then checked, with a model’s help, for whether it says what the claim relies on. Those verdicts can be wrong — read the claim’s quote and the cited source before relying on one.
Statistics and arithmetic are recomputed, not judged.
Confidence bands are shown only for fields calibrated on our annotated test set. None is calibrated yet, so no band is shown.
What counts as a claim ›How we measure confidence ›How we check this ›
Are you an author, or do you see a problem with this page? Request a review
