Cited by 628Polymer crystallization and propertiesWaste Management and RecyclingRecycling and Waste Management Techniques

Expanding plastics recycling technologies: chemical aspects, technology status and challenges

Open access
Li, Houqian, Aguirre-Villegas, Horacio A., Allen, Robert D., Bai, Xianglan, Benson, Craig H., Beckham, Gregg T., Bradshaw, Sabrina L., Brown, Jessica L. +26 more·2022·Green Chemistry

Published version of a preprint

Abstract

This paper reviewed the entire life cycle of plastics and options for the management of plastic waste to address barriers to industrial chemical recycling and further provide perceptions on possible opportunities with such materials.

The claims and statistics of this paper haven’t been checked yet.

Run the check — free, no account needed. It reads the open-access text and checks the sources it cites.

A few free checks a day · papers already verified open instantly · results are public

Integrity signals

Registry

Crossref · 10.1039/d2gc02588d

Cites

716 of 716 references verified0 citation errors · 0 not checkable

Statistics

Claims the paper makes

The claims and statistics of this paper haven’t been checked yet.

Run the check — free, no account needed. It reads the open-access text and checks the sources it cites.

A few free checks a day · papers already verified open instantly · results are public

Claims other papers make about this one

Each is checked against this paper’s own text: does it say what the citing paper says it does?

  • A significant challenge in mechanical recycling is the need for physical separation because mixing different types of plastics leads to macrophase segregated materials with compromised materials properties.

    “A significant challenge in mechanical recycling is the need for physical separation because mixing different types of plastics leads to macrophase segregated materials with compromised materials properties”

    From Chemically recyclable polyolefin-like multiblock polymers (2023) · cites this paper as [6]

    Section 11.2 (page unavailable) says that other plastics reduce the quality of mechanically recycled material, that different plastics are often immiscible, and that separation can produce a more homogeneous feedstock. This supports the need for separation and the concern about compromised properties, but the passage does not establish the claim’s specific description of the resulting material as macrophase segregated. (LLM, conf=0.83)

    Experimental — accuracy not yet measured

Self-check

Percentages, sums and reported differences re-computed from the paper’s own numbers.

The self-check needs the paper’s full text.

Cites

Flagged first, then by citations

Research works printed but not linked: 78

  1. R. C. Thompson, S. H. Swan, C. J. Moore and F. S. Vom Saal, Our Plastic Age, The Royal Society Publishing, 2009, vol. 364, pp. 1973-1976.
  2. S. Allen, D. Allen, F. Baladima, V. Phoenix, J. Thomas, G. Le Roux and J. Sonke, Evidence of Free Tropospheric and Long-Range Transport of Microplastic at Pic Du Midi Observatory, Nat. Commun., 2021, 12(1), 1-10.
  3. C. Benson, Waste containment: Strategies and perform- ance, Aust. Geomech., 2001, 36(4), 1-25.
  4. T. A. Osswald and J. P. Hernández-Ortiz, Polymer proces- sing, Modeling and Simulation, Hanser, Munich, 2006, pp. 1-651.
  5. R. Geyer, J. R. Jambeck and K. L. Law, Production, Use, and Fate of All Plastics Ever Made, Sci. Adv., 2017, 3(7), e1700782.
  6. T. Ren, M. K. Patel and K. Blok, Steam cracking and methane to olefins: Energy use, CO2 emissions and pro- duction costs, Energy, 2008, 33(5), 817-833.
  7. S. S. Chadwick, Ullmann's encyclopedia of industrial chem- istry. Reference Services Review 1988.
  8. IHS_Chemical, PEP Review-Ethylene Process Summary, 2015.
  9. D. Garraín, P. Martínez, R. Vidal and M. J. Bellés, In LCA of thermoplastics recycling, Proc. 3rd International Conference of Life Cycle Assessment. Zurich, Austria. https://www.lcm2007.org/paper/168.pdf accessed July, 2007; p 2008.
  10. T. F. Stocker, D. Qin, G.-K. Plattner, M. Tignor, S. K. Allen, J. Boschung, A. Nauels, Y. Xia, V. Bex and P. M. Midgley, The physical science basis. Contribution of working group I to the fifth assessment report of the intergovernmental panel on climate change, Comput. Geom., 2013, 18(2), 95- 123.
  11. D. Tonini, V. Martinez-Sanchez and T. F. Astrup, Material resources, energy, and nutrient recovery from waste: are waste refineries the solution for the future?, Environ. Sci. Technol., 2013, 47(15), 8962-8969.
  12. OECD)., O. f. E. C. a. D, Municipal Waste. https://www. oecd-ilibrary.org/environment/data/oecd-environment-stat- istics/municipal-waste_data-00601-en (accessed Dec 07).
  13. T. H. Christensen, John Wiley & Sons, Ltd, Chichester, 2010, vol. 1, pp. 319-348.
  14. S. Zhu, H. Chen, M. Wang, X. Guo, Y. Lei and G. Jin, Plastic solid waste identification system based on near infrared spectroscopy in combination with support vector machine, Adv. Ind. Eng. Polym. Res., 2019, 2(2), 77-81.
  15. C. V. Santos and J. A. G. García, El papel de los pepena- dores de materiales reciclables en la gestión de residuos sólidos: los casos de Brasil y México, Revista Legislativa de Estudios Sociales y de Opinión Pública, 2019, 12(24), 87- 114. 120
  16. C. Silva-Chavez, D. Caro and M. Thomsen, Environmental Assessment of Alternatives for Biowaste Treatment in Mexico City, Front. Energy Res., 2019, 7, 30. 128
  17. A. Flores and O. Fairuz, Policy mechanisms to reduce single- use plastic waste. Review of available options and their appli- cability in Mexico, World Resources Institute Mexico, 2020, pp. 50. 132 Netherlands Enterprise Agency, Market opportunities on Circular Economy in Mexico, 2019. 133
  18. M. D. Jagtap, S. S. Khatavkar and T. Z. Quazi, Methods for Waste Plastic Recycling. International Journal on Recent Technologies in Mechanical and Electrical Engineering (IJRMEE) 2 (ISSN: 2349-7947), 120-122. 139
  19. C. Prakash, S. Singh, G. Krolczyk and B. Pabla, Advances in materials science and engineering, Lect. Notes Mech. Eng., 2020, 10, 978-981. 142
  20. M. Paci and F. P. La Mantia, Influence of small amounts of polyvinylchloride on the recycling of polyethyl- eneterephthalate, Polym. Degrad. Stab., 1999, 63(1), 11-14. 158
  21. Z. Wen, Y. Xie, M. Chen and C. D. Dinga, China's plastic import ban increases prospects of environmental impact mitigation of plastic waste trade flow worldwide, Nat. Commun., 2021, 12(1), 1-9. 185
  22. H. Jeswani, C. Kruger, M. Russ, M. Horlacher, F. Antony, S. Hann and A. Azapagic, Life cycle environmental impacts of chemical recycling via pyrolysis of mixed plastic waste in comparison with mechanical recycling and energy recovery, Sci. Total Environ., 2021, 769, 15. 199
  23. Y. Xue, P. Johnston and X. Bai, Effect of catalyst contact mode and gas atmosphere during catalytic pyrolysis of waste plas- tics, Energy Convers. Manage., 2017, 142, 441-451. 202
  24. J. D. Peterson, S. Vyazovkin and C. A. Wight, Kinetics of the Thermal and Thermo-Oxidative Degradation of Polystyrene, Polyethylene and Poly( propylene), Macromol. Chem. Phys., 2001, 202(6), 775-784.
  25. E. A. W. Williams and T. Paul, The Pyrolysis of Individual Plastics and a Plastic Mixture in a Fixed Bed Reactor, J. Chem. Technol. Biotechnol., 1997, 70, 9-20.
  26. D. Zhao, X. Wang, J. B. Miller and G. W. Huber, The Chemistry and Kinetics of Polyethylene Pyrolysis: A Process to Produce Fuels and Chemicals, ChemSusChem, 2020, 13, 1764-1774. 253
  27. S. D. Anuar Sharuddin, F. Abnisa, W. M. A. Wan Daud and M. K. Aroua, A review on pyrolysis of plastic wastes, Energy Convers. Manage., 2016, 115, 308-326. 256
  28. D. Zhao, X. Wang, J. B. Miller and G. W. Huber, The Chemistry and Kinetics of Polyethylene Pyrolysis: A Process to Produce Fuels and Chemicals, ChemSusChem, 2020, 13(7), 1764-1774.
  29. A. B. J. Brems, C. Vandecasteele and R. Dewil, Polymeric Cracking of Waste Polyethylene Terephthalate to Chemicals and Energy, J. Air Waste Manage. Assoc., 2011, 61(7), 721-731. 274
  30. A. H. Tullo, Plastic has a problem; is chemical recycling the solution? https://cen.acs.org/environment/recycling/ Plastic-problem-chemical-recycling-solution/97/i39 (accessed January 15). 280
  31. H. S. Wu, Strategic Possibility Routes of Recycled PET, Polymers, 2021, 13(9), 1475. 283
  32. L. Mingxing, W. Mei, L. Zelong and Z. Qundan, Qualitative and Quantitative Analysis of Silicon Species in Pyrolysis Oil From Waste Plastic, Acta Pet. Sin., 2021, 37(4), 909. 297
  33. M. Y. Wey, C. S. Lo, S. Y. Wu and Y. T. Lee, Operating para- meters of autothermal pyrolysis of plastic waste in a flui- dized bed, Waste Manage. Res., 1998, 16(1), 72-81. 311
  34. Schiers and J. K. Walter, John Wiley & Sons, Ltd, 2006, pp. 475-491. 317
  35. S.-H. Jung, M.-H. Cho, B.-S. Kang and J.-S. Kim, Pyrolysis of a fraction of waste polypropylene and polyethylene for the recovery of BTX aromatics using a fluidized bed reactor, Fuel Process. Technol., 2010, 91(3), 277-284. 320
  36. B. Fekhar, V. Zsinka and N. Miskolczi, Value added hydro- carbons obtained by pyrolysis of contaminated waste plastics in horizontal tubular reactor: In situ upgrading of the pro- ducts by chlorine capture, J. Cleaner Prod., 2019, 241, 118166.
  37. A. Brems, J. B. C. Vandecasteele and R. Dewil, Polymeric Cracking of Waste Polyethylene Terephthalate to Chemicals and Energy, J. Air Waste Manage. Assoc., 2011, 61(7), 721-731.
  38. R. C. Brown, Process Intensification through Directly Coupled Autothermal Operation of Chemical Reactors, Joule, 2020, 4, 2268-2289. 351
  39. A. H. Tullo, ExxonMobil plunges into plastics recycling. https://cen.acs.org/environment/recycling/ExxonMobil- plunges-plastics-recycling/99/i38. 355
  40. Energy, P. Plastic Energy Joins Forces with WWF to Combat Plastic Pollution in Indonesia. https://plasticenergy. com/press-release-plastic-energy-join-forces-with-wwf/. 379
  41. S. M. Al-Salem, A. Antelava, A. Constantinou, G. Manos and A. Dutta, A review on thermal and catalytic pyrolysis of plastic solid waste (PSW), J. Environ. Manage., 2017, 197, 177-198.
  42. A. Maity, S. Chaudhari, J. J. Titman and V. Polshettiwar, Catalytic nanosponges of acidic aluminosilicates for plastic degradation and CO2 to fuel conversion, Nat. Commun., 2020, 11(1), 1-12. 388
  43. L. O. Mark, M. C. Cendejas and I. Hermans, The Use of Heterogeneous Catalysis in the Chemical Valorization of Plastic Waste (ChemSusChem 22/2020), ChemSusChem, 2020, 13, 5773-5773. 402
  44. H. Juwono, L. Fauziah, I. Q. Uyun, R. Alfian, Suprapto, Y. L. Ni'Mah and I. Ulfin, Catalytic Convertion of Al- MCM-41-Ceramic on Hidrocarbon (C8 -C12) Liquid Fuel Synthesis from Polypropylene Plastic Waste, AIP Conf. Proc., 2018, 2049. 404
  45. K. Wanchai and A. Chaisuwan, Catalytic Cracking of Polypropylene Waste over Zeolite Beta, J. Chem. Mater. Res., 2013, 3, 2225-2956.
  46. D. Munir, H. Amer, R. Aslam, M. Bououdina and M. R. Usman, Composite Zeolite Beta Catalysts for Catalytic Hydrocracking of Plastic Waste to Liquid Fuels, Mater, Renewable Sustainable Energy Rev., 2020, 9, 9. 431
  47. S. Salamah, D. Azhari and A. Mitanto, Pyrolysis of Ethylene Vynyl Acetate Polymer by Natural Zeolite Catalyst as an Alternative Fuel, Adv. Eng. Res., 2019, 189, 54-59. 434
  48. S. Salamah and A. Aktawan, Product Distribution of Pyrolysis of Polystyrene Foam Waste using Catalyst of Natural Zeolite and Nickel/Silica, IOP Conf. Series: Earth and Envir. Sci., 2018, 175. 440
  49. N. Miskolczi, C. Wu and P. T. Williams, Pyrolysis of Waste Plastics Using Catalysts: Activated Carbon, MCM-41 and HZSM-5, Int. J. Chem. Eng. Appl., 2017, 8, 67-74. 497
  50. K. Sun, Q. Huang, X. Meng, Y. Chi and J. Yan, Catalytic Pyrolysis of Waste Polyethylene into Aromatics by H3PO4- Activated Carbon, Energy Fuels, 2018, 32, 9772-9781. 498
  51. F. J. Mastral, E. Esperanza, P. García and M. Juste, Pyrolysis of high-density polyethylene in a fluidised bed reactor. Influence of the temperature and residence time, J. Anal. Appl. Pyrolysis, 2002, 63, 1-15. 506
  52. D. Kunii and O. Levenspiel, Fluidization engineering, Butterworth-Heinemann, Boston, London, 1991. 508 Anellotech New Anellotech technology tackles plastics pol- lution by recycling plastic waste into chemicals. https:// anellotech.com/press/new-anellotech-technology-tackles- plastics-pollution-recycling-plastic-waste-chemicals#:~: text=Pearl%20River%2C%20NY%20%E2%80%93% 20December%206,to%20make%20new%2C%20virgin% 20plastics. (accessed Feb 02). 509
  53. P. T. Williams and E. Slaney, Analysis of products from the pyrolysis and liquefaction of single plastics and waste plastic mixtures, Resour., Conserv. Recycl., 2007, 51, 754- 769. 524
  54. A. Okuwaki, T. Yoshioka, M. Asai, H. Tachibana, K. Wakai and K. Tada, The Liquefaction of Plastic Containers and Packaging in Japan, in Feedstock Recycling and Pyrolysis of Waste Plastics: Converting Waste Plastics into Diesel and Other Fuels, ed. J. Scheirs and W. Kaminsky, John Wiley & Sons, 2006, pp. 665-708. 554
  55. Licella Holdings Plastic Waste -Advanced Recycling Feasibility Study, Geelong-Altona Industrial Corridor, Sydney, Australia, 2021; pp. 26-38. 561 Licella Holdings Plastics Cat-HTR™. https://www.licella. com/solutions/plastic/(accessed 2022-01-18). 562
  56. J. Brandrup, E. H. Immergut, E. A. Grulke, A. Abe and D. R. Bloch, Polymer handbook, Wiley, New York, 1999, vol. 89. 590
  57. B. K. C. Sharma, Sriraam Beneficial Use of Plastic Wastes. https://hdl.handle.net/2142/113454 (accessed Feb 02). 607
  58. S. Ugduler, K. M. Van Geem, M. Roosen, E. I. P. Delbeke and S. De Meester, Challenges and opportunities of solvent-based additive extraction methods for plastic re- cycling, Waste Manage, 2020, 104, 148-182. 622
  59. C. M. Hansen, The three dimensional solubility parameter, Danish Technical, Copenhagen, 1967, vol. 14. 655
  60. A. J. Martín, C. Mondelli, S. D. Jaydev and J. Pérez- Ramírez, Catalytic processing of plastic waste on the rise, Chem, 2021, 7(6), 1487-1533. 664
  61. Recycling of polyethylene terephthalate bottles, ed. S. Thomas, A. V. Rane, K. Kanny, V. K. Abitha and M. G. Thomas, William Andrew, Oxford, 2018. 665
  62. G. Güçlü, A. Kaşgöz, S. Özbudak, S. Özgümüş and M. Orbay, Glycolysis of poly(ethylene terephthalate) wastes in xylene, J. Appl. Polym. Sci., 1998, 69(12), 2311-2319.
  63. III. Further investigation, J. Appl. Polym. Sci., 2003, 87(12), 2004-2010. 716
  64. A. M. Al-Sabagh, F. Z. Yehia, D. R. K. Harding, G. Eshaq and A. E. ElMetwally, Fe3O4-boosted MWCNT as an efficient sustainable catalyst for PET glycolysis, Green Chem., 2016, 18(14), 3997-4003.
  65. H. Zahn and H. Pfeifer, Aminolysis of polyethylene tere- phthalate, Polymer, 1963, 4, 429-432.
  66. A. Singh, N. A. Rorrer, S. R. Nicholson, E. Erickson, J. S. DesVeaux, A. F. T. Avelino, P. Lamers, A. Bhatt, Y. Zhang, G. Avery, L. Tao, A. R. Pickford, A. C. Carpenter, J. E. McGeehan and G. T. Beckham, Techno-economic, life-cycle, and socioeco- nomic impact analysis of enzymatic recycling of poly(ethylene terephthalate), Joule, 2021, 5(9), 2479-2503. 801
  67. J. G. Kim, Chemical recycling of poly(bisphenol A carbon- ate), Polym. Chem., 2020, 11(30), 4830-4849. 806
  68. R. Geyer, J. R. Jambeck and K. L. Law, Production, use, and fate of all plastics ever made, Sci. Adv., 2017, 3(7), e1700782. 807
  69. L. Chen, Y. Wu, Y. Ni, K. Huang and Z. Zhu, Depolymerization of polycarbonate in critical region of methanol, Acta Sci. Circumstantiae, 2004, 24(1), 60-64.
  70. J. Kijeński and T. Kaczorek, Catalytic degradation of poly- styrene-Rapid Communication, Polimery, 2005, 50(1), 60- 63. 876
  71. D. Munir, F. Piepenbreier and M. R. Usman, Hydrocracking of a plastic mixture over various micro- mesoporous composite zeolites, Powder Technol., 2017, 316, 542-550. 877
  72. F. Kučera and J. Jančář, Preliminary Study of Sulfonation of Polystyrene by Homogeneous and Heterogeneous Reaction, Chem. Pap., 1996, 50(4), 224-227. 891
  73. V. Wigotsky, Alloys and blends home in on demanding design specs, Plast. Eng., 1988, 44(11), 25-32. 905
  74. R. Rasal, A. Janorkar and D. Hirt, Poly(lactic acid) modifi- cations, Prog. Polym. Sci., 2010, 35, 338-356.
  75. K. Ding, S. Liu, Y. Huang, S. Liu, N. Zhou, P. Peng, Y. Wang, P. Chen and R. Ruan, Catalytic Microwave- Aassisted Pyrolysis of Plastic Waste over NiO and HY for Gasoline-Range Hydrocarbons Production, Energy Convers. Manage., 2019, 196, 1316-1325. 927
  76. T. Sumathi, B. Viswanath, A. Sri Lakshmi and D. SaiGopal, Production of laccase by Cochliobolus sp. isolated from plastic dumped soils and their ability to degrade low molecular weight PVC, Biochem. Res. Int., 2016, 2016. 938 ASTRX ASTRX Review of Material Flow at MRFs and Reprocessors; Sustainable Packaging Coalition and The Recycling Partnership, 2018. 939
  77. J. Aguado, D. P. Serrano and J. M. Escola, Fuels from Waste Plastics by Thermal and Catalytic Processes: A Review, Ind. Eng. Chem. Res., 2008, 47(21), 7982-7992. 945
  78. I. Vollmer, M. J. Jenks, M. C. Roelands, R. J. White, T. van Harmelen, P. de Wild, G. P. van Der Laan, F. Meirer, J. T. Keurentjes and B. M. Weckhuysen, Beyond mechani- cal recycling: Giving new life to plastic waste, Angew. Chem., Int. Ed., 2020, 59(36), 15402-15423.

Cited by

Sorted by citations

Authors
Li, H., Aguirre-Villegas, H. A., Allen, R. D., Bai, X., Benson, C. H., Beckham, G. T., Bradshaw, S. L., Brown, J. L., Brown, R. C., Cecon, V. S., Curley, J. B., Curtzwiler, G. W., Dong, S., Gaddameedi, S., García, J. E., Hermans, I., Kim, M. S., Ma, J., Mark, L. O., Mavrikakis, M., Olafasakin, O. O., Osswald, T. A., Papanikolaou, K. G., Radhakrishnan, H., Sanchez Castillo, M. A., Sánchez-Rivera, K. L., Tumu, K. N., Van Lehn, R. C., Vorst, K. L., Wright, M. M., Wu, J., Zavala, V. M., Zhou, P., & Huber, G. W.
Affiliations
  • University of Wisconsin–Madison (US)
  • Biological Systems Engineering, University of Wisconsin-Madison, Madison, WI, 53706, USA
  • National Laboratory of the Rockies (US)
  • Iowa State University (US)
  • Department of Chemical and Biological Engineering, University of Wisconsin-Madison, Madison, WI, 53706, USA
  • Facultad de Ciencias Químicas, Universidad Autónoma de San Luis Potosí, San Luis Potosí 78210, Mexico
Corresponding author
Huber, George W.
Venue
Green Chemistry
Published
2022
Volume
24
Issue
23
Pages
8899-9002
ISSN
  • 1463-9262 (ISSN-L)
  • 1463-9270
OpenAlex
W4295788330
Cited by
616
References
715
Citations by year
2026: 141 · 2025: 185 · 2024: 169 · 2023: 106 · 2022: 15
FWCI
38.09
Type
journal article
Language
en
Open access
Locations
  • Green Chemistry (publishedVersion, cc-by)
  • ChemRxiv (acceptedVersion, cc-by-nc-nd)
  • Lirias (acceptedVersion, cc-by)
  • Iowa State University Digital Repository (Iowa State University) (submittedVersion)
  • OSTI OAI (U.S. Department of Energy Office of Scientific and Technical Information) (submittedVersion)
Funders
U.S. Department of Energy (DE-EE0009285)
Topics
  • Physical Sciences › Materials Science › Polymers and Plastics › Polymer crystallization and properties
  • Physical Sciences › Environmental Science › Waste Management and Disposal › Waste Management and Recycling
  • Physical Sciences › Environmental Science › Waste Management and Disposal › Recycling and Waste Management Techniques
Keywords
plastic recycling, chemical recycling, plastic waste management, plastic life cycle, barriers to recycling, recycling technology

About these checks

Registry, retraction, Cites and statistics results are computed, not judged, with one exception: a printed reference that no index lists is read once by a model before it counts as a citation error. Claims are extracted by a model and kept only when their quote appears verbatim in the text; each cited source is then checked, with a model’s help, for whether it says what the claim relies on. Those verdicts can be wrong — read the claim’s quote and the cited source before relying on one.

Statistics and arithmetic are recomputed, not judged.

Confidence bands are shown only for fields calibrated on our annotated test set. None is calibrated yet, so no band is shown.

What counts as a claim ›How we measure confidence ›How we check this ›

Are you an author, or do you see a problem with this page? Request a review